Lexus SC300 SC400 SC430 1991-2010 Workshop Repair Service Manual PDF - MLXSC9110OPES.zip
This all-inclusive workshop manual provides service, upkeep, and diagnostic guidance for the 1991-2010 Lexus SC300, SC400, and SC430. Diagnostic and repair instructions are presented in thorough detail, letting you fix, service, rebuild, refurbish, or bring your vehicle back to its best just as a trained technician would in a neighborhood repair shop. This affordable, high-quality manual is entirely complete and undamaged, with no pages absent. It matches the official dealer factory manual and is guaranteed to work flawlessly, helping you make the most of your valuable time.
The 1991-2010 Lexus SC300, SC400, SC430 manual is organized into separate sections. Every section focuses on one particular component or system and, alongside routine service procedures, offers directions for taking apart, examining, and reassembling parts. Each section opens with its own table of contents. Pages can be located quickly by category, and every page can be enlarged to reveal fine detail. Delivered as a cross-platform PDF, it performs perfectly on any type of device. No computer expertise is required to navigate the manual.
SC300, SC400 '92-'01...88
Introduction...88
How to Use This Manual...91
Bolt Torque Specs...89
Identification Information...94
Total Diagnostic Comm. Link...97
SRS Precautions...98
Catalytic Converter Precautions...102
Traction Control Precautions...103
Propeller Shaft Inspection...104
Troubleshooting ECU...105
Vehicle Lift and Support Locations...123
Air Conditioning...124
ac retrofit r12 r134a.pdf...125
Air Conditioning...129
Description...134
Preparation...141
Use of Manifold Gauge Set...143
Recovering Refrigerant ...144
Evacuating Air In Regrig. System...145
Troubleshooting...148
Problem Analysis Check Sheet...151
Diagnosis...152
Diagnostic Code Chart...154
Terminals of ECU...157
Starndard Value of ECU...158
Wiring Diagram...161
Matrix Chart of Problem Symptoms...162
Connector Locations...164
Circuit Inspection...170
Ambient Temp. Sensor...172
Evap. Temp. Sensor...174
Water Temp. Sensor...176
Solar Sensor...178
Compressor Lock Sensor...180
ac-56.pdf...182
Air Mix Damper Position Sensor...184
Air Mix ServoMotor ...186
Air Inlet Damper Position Sensor...188
Air Inlet Servomotor...190
Air Outlet Damper Position Sensor...192
Air Outlet Servomotor...194
IG Power Source...196
ACC Power Source...198
Back-up Power Source...200
Heater Main Relay...202
Power Transistor...204
Blower Motor...206
Igniter Circuit...208
Compressor...210
Water Valve VSV...215
Temp. Control Switch...217
Automatic Control Switch...220
Diagnosis...222
Inspecting Refrigerant System...224
Refrigerant Volume...227
Drive Belt Tension...228
Refrigerant Lines...229
AC Unit...231
Compressor...234
Receiver...242
Condenser...244
Evaporator...246
Heater Radiator...249
Expansion Valve...250
Water Valve...251
Blower Motor...253
Blower Resistor...256
Air Inlet Servomotor...254
Air Outlet Servomotor...255
Ambient Temp. Sensor...257
Solar Sensor...258
Revolution Detecting Sensor...259
Water Temp. Sensor...260
Installing Pressure Switch...262
AC Control ...263
Service Specifications...264
ABS...265
Open In Front Airbag Sensor...271
Airbag Warning Light System...277
Center Airbag Sensor...283
Malfunction Stored In Memory...285
Airbag Warning Light Always Lit...287
TC Terminal...289
Disposal of Steernig Wheel Pad...294
Service Specs...301
SRS Airbag...302
Operation...306
Inspection and Replacement Requirements...310
Preparation...314
Removal and Installation of Components...315
Front Airbag Sensor...317
Center Airbag Sensor...319
Replacement of Repair Wire For Front Airbag Sensor...321
Troubleshooting...324
Proceeding ...326
Problem Analysis Check Sheet...330
Diagnosis Inspection...331
Wiring Diagram...334
Diagnostic Code Matrix Chart...335
Connector Locations...337
Circuit Inspection...341
Short in Squib Circuit or Front Airbag Sensor...343
Short in Squib Circuit or Front Airbag Sensor...349
Short in Squib Circuit Between D+ and D- Wire Harness...355
Automatic Transmission...363
Troubleshooting 1UZ-FE...365
Problem Symptom Confirmation...369
Automatic Shift Schedule...373
Preliminary Check...375
Mechanical System Tests...378
Manual Shifting Test...387
Diagnostic Trouble Code Chart...388
Standard Value of ECM Terminal...391
Matrix Chart of Problem Symptoms...393
Connector Locations...400
Vehicle Speed Sensor...406
#4 Solenoid Valve...409
#2 Vehicle Speed Sensor...413
#1,2 Solenoid Valve...417
#3 Solenoid Valve...421
O/D Direct Clutch Speed Sensor Circuit...425
Throttle Position Sensor ...429
Kick-Down Switch...431
Park/Neutral Position Switch...433
Stop Light Switch...435
Pattern Select Switch...437
O/D Main Switch and O/D OFF Light...439
O/D Cancel Signal...443
TE1 Terminal...445
TT Terminal...447
Service Specifications...448
A340E Automatic Transmision...451
Assembly, Removal, Installation...473
Operation...454
Preparation...461
Troubleshooting...481
Extension Housing...464
Speed Sensor...466
Park/Neutral Position Switch...468
Valve Body...469
Shift Lock...477
Body...485
Inner Rear View Mirror...487
Windshield ...488
Quarter Window Glass...495
Back Window Glass...497
Front Seat...501
Rear Seat...509
Seat Belt...513
Front...514
Rear...516
Luggage Compartment...517
Door...518
Trim and Weatherstrip...521
Moon Roof...524
Sliding Roof...526
Front Fender...534
Emblem...537
Moulding...539
Back Window Moulding...542
Body Outside Moulding...544
Mud Guard...547
Rear Spoiler...548
Fuel Lid...549
Instrument Panel...550
Floor Carpet...558
Roof Headlining...561
Trim, Assist Grip, and Visor...563
Body Dimensions...569
Drawings...570
Suspension Crossmember ...577
Service Specifications...580
Body...582
Preparation...590
Front Bumper...592
Rear ...596
Hood...599
Components...600
Related Parts...603
Lock Control...605
Transport Hook...608
Removal...610
Door ...611
Components...613
Body Electrical...624
Coolant Level Warning Switch...625
Power Window Control...626
Liquid Crystal Inner Mirror...637
Tension Reducer...640
Defogger...644
Sliding Roof...649
Power Mirror Control...656
Fuel Lid Opener...664
Clock...667
Audio System...669
Horn ...735
Driver Power Seat Control ...738
Location...740
Troubleshooting...741
Problem Analysis Check Sheet...743
Wiring Diagram...744
Standard Value of ECU Terminal...745
Matrix of Problem Symptoms...747
Connector Locations...749
Circuit Inspection...755
ECU Power Source...757
Motor Circuit...759
Position Sensor Power Source...762
Position Sensor...764
Stop Light Circuit...768
Neutral Start Switch...770
Ignition Switch...772
Power Seat Switch...774
Serial Comm. Circuit...776
Power Seat Control...778
Location...781
Troubleshooting...782
Problem Analysis Check Sheet...784
Wiring Diagram...785
Standard Value of ECU Terminal...786
Matrix Chart of Problem Symptoms...787
Connector Locations...788
Circuit Inspection...792
Slide Motor Power Source...794
Slide Motor Circuit...796
Position Sensor...798
Slide Switch Circuit...802
Buckle Switch...806
Limit Switch...808
Reclining Switch and Motor...811
Door Lock Control...814
Description...816
Troubleshooting...818
Problem Analysis Check Sheet...820
Wiring Diagram...821
Terminals of ECU...822
Standard Value of ECU Terminal...823
Matrix Chart of Problem Symptoms...825
Connector Locations...826
Circuit Inspection...830
Actuator Power Source...832
Door Lock Motor...834
Luggage Compartment Door Opener...836
Door Lock Control Circuit...838
Door Key Lock and Unlock Switch...840
Key Unlock Warning Switch...842
Luggage Compartment Door Opener Main Switch...844
Door Open Detection Switch...846
Wireless Door Lock Control...849
Location...851
Replacement...860
Wiring Diagram...863
Troubleshooting...853
Problem Analysis Check Sheet...855
Precheck 1...856
Preckeck 2...857
Transmitter Inspection...858
Antenna Circuit Inspection...859
Standard Value of ECU Terminal...864
Matrix Chart of Problem Symptoms...865
Connector Locations...867
Circuit Inspection...871
Door Unlock Detection Switch...873
Door Key Lock/Unlock Switch ...875
be-466.pdf...877
Key Unlock Warning Switch...879
Door Open Detection Switch...881
Body Electrical...884
Precautions...890
Preparation...891
Power Source...893
Ignition Switch...908
Lighting System...911
Headlights...913
Location...916
Wiring Diagram...917
Connector Diagrams...919
Replacement...920
Inspection...922
Defogger...934
Taillight...939
Wiring and Connector Diagrams...940
Replacement...941
Inspection...943
Troubleshooting...944
Stop Light...945
Wiring and Connector Diagrams...946
Replacement...947
Troubleshooting...950
Turn Signal and Hazard...951
Wiring and Connector Diagrams...952
Replacement...953
Inspection...954
Troubleshooting...956
Illumination Light ...957
Wiring and Connector Diagrams...958
Inspection...959